王春梅;周红秀;杜宝国;邱硕;
大连理工大学能源与动力学院
摘要：利用KIVA3数值模拟研究柴油以及三种生物柴油(大豆油甲酯、棕榈油甲酯、麻疯油甲酯)对压燃发动机燃烧和排放性能的影响。数值计算结果表明:生物柴油在燃烧初始阶段与柴油燃烧特性基本一致,燃烧中后期,生物柴油的平均缸温低于柴油,其中麻疯油甲酯最为明显;生物柴油碳烟和CO生成量明显低于柴油。生物柴油虽然缸内氧含量比柴油高,但由于受缸温的影响,NOx排放比柴油低,而麻疯油甲酯在三种生物柴油中NOx排放最低。
关键词： 压燃发动机;;生物柴油;;KIVA3;;燃烧性能;;排放性能
Abstract: Numerical Simulation were
performed in KIVA 3 to investigate the effect of three kinds of
biodiesel(soybean oil methyl ester,palm oil methyl ester and Jatropha oil
methyl ester) on the combustion characteristics and emissions formation
processes in a compression-ignition engine,compared with that of diesel fuel
respectively.The results showed that biodiesels and diesel combustion
characteristics were basically the same during the initial stage of
combustion,and in the late combustion,the average cylinder temperature of
biodiesels were lower than that of diesel,especially Jatropha oil methyl
ester.Biodiesels produced lower soot and CO emissions than diesel fuel.Because
of the effect of the cylinder temperature,biodiesel produced lower NOxthan
diesel.Among these biodiesels,NOxemission of Jatropha oil methyl ester was
lowest.
Keywords: Compression-ignition
Engine;;Biodiesel;;KIVA3;;Combustion Performance,Emission Performance
基金项目: 大连理工大学基本科研业务费专项项目资助(DUT13JN12)
参考文献：
[1]边耀璋等.汽车新能源技术[M].北京:人民交通出版社,2003.
[2]李昌珠,蒋丽娟等.生物柴油——绿色能源[M].北京:化学工业出版社,2005.
[3]何凤苗,雷昌菊,江香梅等.生物质能源——生物柴油研究进展[J].江西林业科技,2007,1:45-49.
[4]赵宗保,华艳艳,刘波等.中国如何突破生物柴油产业的原料瓶颈[J].中国生物工程杂志,2005,25(11):1-6.
[5]李远超,王建黎,计建炳等.生物柴油工业化生产的现状及其经济可行性评估[J].中国油脂,2005,5:59-64.
[6]XUE J L,GRIFT E T,HANSEN A C.Effect of
biodiesel on engine performances and emissions[J].Renewable and Sustainable
Energy Reviews,2011,15(2):1098-1116.
[7]葛蕴删,张世鹰,郝利君等.生物柴油在柴油机中的应用研究[J].内燃机工程,2004,24(2):12-14.
[8]张春化,宋建桐.燃用生物柴油增压柴油机的性能和排放[J].交通运输工程学报,2008(2):18-21.
[9]REKSOWARDOJO I K,Lubis H I,WISHNU S A
M.Performance and exhaust gas emissions of using biodiesel fuel from physic
nut(Jatropha Curcas L)oil on a direct injection diesel engine(DI).SAE
paper,2007-01-2025,2007.
[10]SURYAWANSHI J G.Performance and
emission characteristics of CI engine fueled by coconut oil methyl ester.SAE
paper,2006-32-0077,2006.
[11]AMSDEN A A,RAMSHAW J D,O'Rourke P J,et
al,KIVA:A computer program for two and three dimensional fluid flows with
chemical reactions and fuel sprays,Los Alamos National Laboratory
report,LA-10245-MS,1985.
[12]曹文明.生物柴油国内外研究应用综述[C].上海市粮油学会,2005年学术年会论文汇编.上海.2005:122-132.
[13]李玉琦.二甲醚、生物柴油及其混合燃料物性估算和缸内工作过程模拟研究[D].北京:北京交通大学,2008.
[14]林璟,方利国.GC/MS法测定五种生物柴油中脂肪酸甲酯的研究[J].化学与生物工程,2008,8:76-78.
[15]陈苗,马美湖,杨湄等.棕榈油甲酯的制备及饱和与不饱和脂肪酸甲酯的分离研究[C].第八届蛋品科技大会.
[16]Ng H K,Gan S,Ng J H,et al..Simulation
of biodiesel combustion in a light-duty diesel engine using integrated compact
biodiesel-diesel reaction mechanism.Applied Energy,2013,102:1275–1287.
|
