邢登军,滕勤,谈建
合肥工业大学机械与汽车工程学院
摘要：采用非线性建模方法研究了发动机热式空气质量流量(MAF)传感器的动态特性。基于静、动态标定数据,用两步辨识法建立了传感器的Hammerstein模型。建立多幅值激励下的模型时,充分考虑了激励信号源的延迟特性,并采用3种不同的方法对传感器的实际输入进行了估计。利用建立的模型分别计算了热线式和热膜式MAF传感器的时域和频域性能指标,并进行了分析和比较。结果表明,MAF传感器的动态响应特性与激励信号的大小有关,在发动机瞬态空燃比控制策略中应该采取措施补偿由于传感器变延迟特性引起的动态测量误差。
关键词： 热式空气质量流量传感器;动态响应;时域指标;频域指标
Abstract：The dynamic characteristics of a thermal mass air flow(MAF) sensor
for engine are studied using nonlinear modeling method.Based on static state
and dynamic state calibration experiment data,the Hammerstein model is
established by a two-step identification method.During modeling under
multi-magnitude excitation,the delay characteristics of the excitation signal
source was considered sufficiently,and the actual inputs acting on the sensor
were estimated with three kinds of different methods.In terms of the established
models,the time domain and frequency domain performance indices of the hot wire
type and the hot film type MAF sensors were calculated and
analyzed,respectively.Results show that the dynamic response characteristics of
the MAF sensors are related to magnitudes of excitation signal,and that some
schemes for the engine transient air fuel ratio control strategies should be
adopted to compensate for dynamic measurement errors resulting from the
sensor's variable delay behaviors.
Keyword：Thermal Mass Air Flow Sensor;Dynamic Response;Time Domain
Index;Frequency Domain Index
参考文献:
[1]Kaidantzis P,Rasmussen P,Jensen M,et
al.AdvancedNonlinear Observer Control of SI
Engines,930768[R].Warrendale,U.S.:Society of Automotive Engineers,SAETechnical
Paper,1993.
[2]Corde G,Bianco Y,Lecluse Y.Air Mass Flow
Rate ObserverApplied to SI AFR Control,952460[R].Warrendale,U.S.:Society of
Automotive Engineers,SAE Technical Paper,1995.
[3]Powell J D,Fekete N P,Chang C
F.Observer-Based AirFuel Ratio Control[J].IEEE Control Systems
Magazine,1998,18(5):72-83.
[4]Kotwicki A,Russell J,Pursifull R,et
al.An Air Meter BasedCylinder Air Charge
Estimator,1999-01-0856[R].Warrendale,U.S.:Society of Automotive
Engineers,SAETechnical Paper,1999.
[5]Tan D R,Liu Z Y,Wang J H.Study on
Optimum EstimateMethod for Gasoline Engine Intake Flowrate Based on
StateObserver[C].Proceedings of the 6th World Congress onIntelligent Control
and Automation,Dalian,China,June 21-23,2006.
[6]Hendricks E,Jensen M,Chevailler A,et
al.ConventionalEvent Based Engine Control,940377[R].Warrendale,U.S.:Society of
Automotive Engineers,SAE Technical Paper,1994.
[7]Sekozawa T,Takahashi S,Shioya M,et
al.Development of aHighly Accurate Air-Fuel Ratio Control Method Based
onInternal State Estimation,920290[R].Warrendale,U.S.:Society of Automotive
Engineers,SAE Technical Paper,1992.
[8]Hendricks E,Jensen M,Kaidantzis P,et
al.Transient A/FRatio Errors in Conventional SI Engine
Controllers,930856[R].Warrendale,U.S.:Society of Automotive Engineers,SAE
Technical Paper,1993.
[9]Follmer W C.Frequency Domain
Characterization of Mass AirFlow Sensors,880561[R].Warrendale,U.S.:Society
ofAutomotive Engineers,SAE Technical Paper,1988.
[10]Ziesmer D A,Chuey M D,Hazelton
L.Frequency DomainCharacterization of Mass Airflow
Sensors,930325[R].Warrendale,U.S.:Society of Automotive Engineers,SAETechnical
Paper,1993.
[11]Mrad R B,Levitt J A.Nonlinear Process
RepresentationUsing ARMAX Models with Time Dependent
Coefficients[C].Proceedings of the 37th IEEE Conference on Decision
andControl,Tampa,Florida U.S.,1998:495-500.
[12]吴克刚.热膜式空气质量流量传感器的动态响应[J].长安大学学报(自然科学版),2005,22(5):99-102.
[13]Tanimoto K,Bessho M,Inada M.Switching
ControlledThermal Mass Air Flow Sensor,890298[R].Warrendale,U.S.:Society of
Automotive Engineers,SAE Technical Paper,1989.
[14]Sauer R.Hot Film Air Mass Meter-A Low
Cost Approach toIntake Air Measurement,880560[R].Warrendale,U.S.:Society of
Automotive Engineers,SAE Technical Paper,1988.
[15]Xu Ke-Jun,Ren Hao,Wang Xiao-Fen,et
al.Non-linear Dynamic Modeling of Hot-film/wire MAF Sensors withTwo-stage
Identification Based on Hammerstein Model[J].Sensors and
Actuators,A:Physical,2007,135(1):131-140.
[16]滕勤,马标,徐科军.热膜式空气质量流量传感器块联模型结构辨识[J].仪器仪表学报,2008,29(3):477-482.
[17]滕勤,马标,徐科军.热线式空气质量流量传感器Hammerstein模型结构辨识[J].系统仿真学报,2008,20(7).
[18]Chang C F,Fekete N P,Powell J D.Engine
Air-Fuel RatioControl Using an Event-Based
Observer,930766[R].Warrendale,U.S.:Society of Automotive Engineers,SAETechnical
Paper,1993.
[19]Aono T,Kowatari T.Throttle-Control
Algorithm forImproving Engine Response Based on Air-Intake Model
andThrottle-Response Model[J].IEEE Transactions on
IndustrialElectronics,2006,53(3):915-921.
[20]Rossi C,Tilli A,Tonielli A.Robust
Control of a ThrottleBody for Drive by Wire Operation of Automotive
Engines[J].IEEE Transactions on Control Systems Technology,2000,8(6):993-1002.
|
